Chemistry, Physics and Technology of Surface, 2025, 16 (1), 28-38.

Nanoporous carbon adsorbents for water purification from phenol compounds



DOI: https://doi.org/10.15407/hftp16.01.028

V. О. Sabierova, Yu. V. Таmarkina, A. V. Redko, V. O. Kucherenko

Abstract


The purpose of the work is to compare the adsorption of phenol (P) and 4-chlorophenol (CP) by activated carbons (ACs) from coals and coking semi-products (CSPs).

The ACs with specific surface SDFT = 1009–1547 m2/g were prepared by alkaline activation at a KOH/substrate ratio of 1 g/g (800 °С, 1 h). The characteristics of ACs porosity were calculated by nitrogen adsorption – desorption isotherms (–196 °С). The adsorption capacities for P (АP) and CP (АCP) were measured at 25 °C, АC dosage – 1 g/l and concentration 5 mmol/l. The specific adsorption capacities (АP(S), АCP(S)) and the initial adsorption rates of P (VP) and CP (VCP) for the first 5 minutes of adsorption were also determined. The coal and CSP type were established to determine the porosity and adsorption activity of ACs. Adsorption kinetics obeys the pseudo-second order model (R2 ≤ 0.996). The maximum capacities are AP(m) = 1.52–3.11 mmol/g and ACP(m) = 1.63–3.87 mmol/g. Initial rates are VP = 0.096–0.258 mmol/g·min and VCP = 0.107–0.607 mmol/g·min. With an SDFT increase, the values of AP(m) and ACP(m) increase linearly. It was found that the specific capacities, which are proportional to the surface concentration of adsorption centers (AdCs), decrease linearly with the SDFT growth for ACs from coals. The opposite trend was found for ACs from CSPs. All samples adsorb CP better than phenol in proportion of АCP(S) = 1.455·АP(S)–0.456 (R2 = 0.944). The AdCs concentration increase was found to increase the CP specific adsorption rate. The opposite effect is observed for phenol – an AdCs concentration increase decreases the rate probably due to decreasing the energy of the interaction of P with AdCs. The ACs from low-rank coals were shown to be the most active adsorbents. The SPCs also improve adsorption properties, which makes promising their use for ACs preparation.


Keywords


coal; semi-product of coking; activated carbon; adsorption; phenol; 4-chlorophenol

References


1. Xing B.-L., Go H., Chen L.-J., Chen Z.-F., Zhang C.-X., Huang G.-X., Yu J.-L. Lignite-derived high surface area mesoporous activated carbons for electrochemical capacitors. Fuel Process. Technol. 2015. 138: 734. https://doi.org/10.1016/j.fuproc.2015.07.017

2. Zhao X.-Y., Huang S.-S., Cao J.-P., Xi S.-C., Wei X.-Y., Kamamoto J., Takarada T. KOH activation of a HyperCoal to develop activated carbons for electric double-layer capacitors. J. Anal. Appl. Pyrolysis. 2014. 105: 116. https://doi.org/10.1016/j.jaap.2013.10.010

3. Chesnokov N.V., Mikova N.M., Ivanov I.P., Kuznetsov B.N. Synthesis of carbon sorbents by chemical modification of fossil coals and plant biomass. SibFU Journal (Chemistry). 2014. 7(1): 42.

4. Chen W., Luo M., Yang K., Zhou X. Microwave-assisted KOH activation from lignin into hierarchically porous carbon with super high specific surface area by utilizing the dual roles of inorganic salts: Microwave absorber and porogen. Microporous Mesoporous Mater. 2020. 300: 110. https://doi.org/10.1016/j.micromeso.2020.110178

5. Ganesan A., Shaijumon M.M. Activated graphene-derived porous carbon with exceptional gas adsorption properties. Microporous Mesoporous Mater. 2016. 220: 21. https://doi.org/10.1016/j.micromeso.2015.08.021

6. Wei F., Zhang H., He X., Ma H., Dong S., Xie X. Synthesis of porous carbons from coal tar pitch for high-performance supercapacitors. New Carbon Mater. 2019. 34(2): 132. https://doi.org/10.1016/S1872-5805(19)60006-5

7. Javed H., Luong D.X., Lee C.-G., Zhang D., Tour J.M., Alvarez P.J.J. Efficient removal of bisphenol-A by ultra-high surface area porous activated carbon derived from asphalt. Carbon. 2018. 140: 441. https://doi.org/10.1016/j.carbon.2018.08.038

8. Tiwari D., Bhunia H., Bajpai P.K. Adsorption of CO2 on KOH activated, N-enriched carbon derived from urea formaldehyde resin: kinetics, isotherm and thermodynamic studies. Appl. Surf. Sci. 2018. 439: 760. https://doi.org/10.1016/j.apsusc.2017.12.203

9. Tamarkina Yu.V., Anishchenko V.M., Red'ko A.M., Kucherenko V.O. Alkali activated coals. Microporous structure and capability to adsorb phenol compounds. Him. Fiz. Tehnol. Poverhni. 2022. 13(1): 111. [in Ukrainian]. https://doi.org/10.15407/hftp13.01.111

10. Kucherenko V.A., Tamarkina Yu.V., Mysyk R.D. Properties of adsorbents, obtained by alkaline acyivation of long-flame coal with secondary coking products. Ughlekhymycheskyj Zhurnal. 2016. 6: 35. [in Russian].

11. Czaplicka M. Sources and transformations of chlorophenols in the natural environment. Sci. Total Environ. 2004. 322(1-3): 21. https://doi.org/10.1016/j.scitotenv.2003.09.015

12. Ahmed M.J., Theydan S.K. Adsorption of p-chlorophenol onto microporous activated carbon from Albizia lebbeck seed pods by one-step microwave assisted activation. J. Anal. Appl. Pyrolysis. 2013. 100: 253. https://doi.org/10.1016/j.jaap.2013.01.008

13. Chen C., Geng X., Huang W. Adsorption of 4-chlorophenol and aniline by nanosized activated carbons. Chem. Eng. J. 2017. 327: 941. https://doi.org/10.1016/j.cej.2017.06.183

14. Peng Y., Chen J., Lu S., Huang J., Zhang M., Buekens A., Yan J. Chlorophenols in municipal solid waste incineration: a review. Chem. Eng. J. 2016. 292: 398. https://doi.org/10.1016/j.cej.2016.01.102

15. Ding H., Li X., Wang J., Zhang X., Chen C. Adsorption of chlorophenols from aqueous solutions by pristine and surface functionalized single-walled carbon nanotubes. J. Environ. Sci. 2016. 43: 187. https://doi.org/10.1016/j.jes.2015.09.004

16. Kucherenko V.O., Tamko V.O., Shendrik T.G., Shevkoplias V.M. Thermolysis of long-flame coal with wastes of coke chemical plants: process and its producats. Voprosy Khimii Khim. Tekhnol. 2017. 4(111): 56. [in Ukrainian].

17. Jagiello J., Olivier J.P. 2D-NLDFT adsorption models for carbon slit-shaped pores with surface energetical heterogeneity and geometrical corrugation. Carbon. 2013. 55: 70. https://doi.org/10.1016/j.carbon.2012.12.011

18. Wu J., Montes V., Virla L.D., Hill J.M. Impacts of amount of chemical agent and addition of steam for activation of petroleum coke with KOH or NaOH. Fuel Process. Technol. 2018. 181: 53. https://doi.org/10.1016/j.fuproc.2018.09.018

19. Thommes M., Kaneko K., Neimark A.V., Olivier J.P., Rodriguez-Reinoso F., Rouquerol J., Sing K.S.W. Physisorption of gases, with special reference to the evaluation of surface area and pore size distribution (IUPAC Technical Report). Pure Appl. Chem. 2015. 87(9-10): 1051. https://doi.org/10.1515/pac-2014-1117

20. Lorenc-Grabowska E., Rutkowski P. High basicity adsorbents from solid residue of cellulose and synthetic polymer co-pyrolysis for phenol removal: kinetics and mechanism. Appl. Surf. Sci. 2014. 316: 435. https://doi.org/10.1016/j.apsusc.2014.08.024

21. Tamarkina Yu.V., Anishchenko V.M., Redko A.M., Kucherenko V.A. Adsorption of phenol by activated carbons based on fossil coals of various degrees of metamorphism. Solid Fuel Chem. 2021. 55(3): 133. https://doi.org/10.3103/S0361521921030101

22. Wu F.-C., Wu P.-H., Tseng R.-L., Juang R.-S. Preparation of novel activated carbons from H2SO4-pretreated corncob hulls with KOH activation for quick adsorption of dye and 4-chlorophenol. J. Environ. Manag. 2011. 92(3): 708. https://doi.org/10.1016/j.jenvman.2010.10.003

23. Ho Y., McKay G. Pseudo-second order model for sorption processes. Process Biochem. 1999. 34(5): 451. https://doi.org/10.1016/S0032-9592(98)00112-5




DOI: https://doi.org/10.15407/hftp16.01.028

Copyright (©) 2025 V. О. Sabierova, Yu. V. Таmarkina, A. V. Redko, V. O. Kucherenko

Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 International License.